Shift Problems

Moderator: Founder

Shift Problems

Postby Cruzer » 13 May 2015, 11:17

Just checked in to a new unit and a couple vehicles are down due to not shifting. I've replaced (M1152) TCM, TISS/TOSS, pressed the reset button. I hook a supershifter into the TCM to manually shift and shifts without a problem. I Diagnosed with the Supershifter but no codes pull. Any ideas as to what it can be? The transmission light does illuminate.
Cruzer
Newb
Newb
 
Posts: 5
Joined: 07 Sep 2014, 04:04

Re: Shift Problems

Postby SgtCathers » 14 May 2015, 16:35

Does your transmission light come on at all? If not pull the wires out of the reset button and plug them together if the light comes on the circuit breaker is bad.Also check your Throttle Position Sensor, if it is out of adjustment will prevent from shifting. One thing I would also check, it's amazing but I've seen it, the tiss and toss wires to make sure they are not switched around.
SgtCathers
It's Already Fixed
 
Posts: 199
Joined: 27 Sep 2011, 08:20
Location: 3rd Battallion, 3rd Marines, MCBH

Re: Shift Problems

Postby Cruzer » 15 May 2015, 10:28

Transmission light does illuminate. I'm getting 12V to the reset button wires. I can't image the tiss/toss wires were switched around but anything is possible in this case. I'll follow up with an update if or when I figure it out.
Cruzer
Newb
Newb
 
Posts: 5
Joined: 07 Sep 2014, 04:04

Re: Shift Problems

Postby Petz » 01 Jul 2015, 12:20

Check the fuel line on the back of the engine leading into the fuel water seperator. If the engine was replaced there is a good chance they didn't cut it down to size and the fuel is being restricted at higher RPMs. This will cause the vehicle to seem as though it's not shifting.

The way to test this is by slowly bringing the vehicle to Wide Open Throttle (WOT). If the engine begins to sputter then it's a fuel problem.

Note** I've had issues further down the fuel supply line that have caused the same issue. There is a one way check valve in-line on the fuel feed that had a small plastic burr stuck in it causing the same issue as the above mentioned issue.
Petz
It's Already Fixed
 
Posts: 283
Joined: 01 Jan 2011, 05:43
Location: Camp Kinser, JP

Re: Shift Problems

Postby usmcak » 12 Dec 2017, 08:22

having some what of the same issue. just replaced the transmission and it wont shift out of 1st. now its just screaming down the road.

*also the speedometer isn't working as well, if that has anything to do with it. *
"It's not how many years in your life that count, it's the life in your years." - Abraham Lincoln
User avatar
usmcak
It's Already Fixed
 
Posts: 120
Joined: 31 May 2011, 10:56
Location: Boise Idaho

Re: Shift Problems

Postby SUPERMOD » 12 Dec 2017, 08:49

it wont shift out of 1st or is it stuck in 2nd?
SuperMod
3521/0411/0916

"IF YOU DONT LIVE FOR SOMETHING, YOU DIE FOR NOTHING"
User avatar
SUPERMOD
Site Founder
Site Founder
 
Posts: 910
Joined: 02 Jun 2010, 16:33
Location: Camp Pendleton, Ca

Re: Shift Problems

Postby usmcak » 12 Dec 2017, 09:34

I took it out on a road test, it shifted out of first and into second once. We stopped and turned around. Came back to the base and I tried to troubleshoot the speedometer. Now literally time now, I start it up and now it won’t move. The engine oil was low so we filled that up to specs. But now the damn thing won’t move.
"It's not how many years in your life that count, it's the life in your years." - Abraham Lincoln
User avatar
usmcak
It's Already Fixed
 
Posts: 120
Joined: 31 May 2011, 10:56
Location: Boise Idaho

Re: Shift Problems

Postby usmcak » 12 Dec 2017, 09:37

Now I mashed on the pedal, in revesre. We are moving again for the moment, we are taking it on another road test.
"It's not how many years in your life that count, it's the life in your years." - Abraham Lincoln
User avatar
usmcak
It's Already Fixed
 
Posts: 120
Joined: 31 May 2011, 10:56
Location: Boise Idaho

Re: Shift Problems

Postby usmcak » 12 Dec 2017, 09:52

Just got back from our short test drive. No joy. It still won’t shift out of first. Tried to move the transmission selector to D, 2, and 1 and it was doing anything.
"It's not how many years in your life that count, it's the life in your years." - Abraham Lincoln
User avatar
usmcak
It's Already Fixed
 
Posts: 120
Joined: 31 May 2011, 10:56
Location: Boise Idaho

Re: Shift Problems

Postby SUPERMOD » 12 Dec 2017, 10:46

do you have a tran-x? I think you actually might be in 2nd this whole time. need to know because that will make the difference.

also what kinda HMMWV?
did you click the reset behind drivers seat?
SuperMod
3521/0411/0916

"IF YOU DONT LIVE FOR SOMETHING, YOU DIE FOR NOTHING"
User avatar
SUPERMOD
Site Founder
Site Founder
 
Posts: 910
Joined: 02 Jun 2010, 16:33
Location: Camp Pendleton, Ca

Next

Return to Transmission/Drivetrain

Who is online

Users browsing this forum: No registered users and 1 guest